Volant Tundra User Manual
Page 2
38857
1.
Install the snorkel adapter to the Volant box with the hardware
provided.
2.
Tape the snorkel templete to the fender and center punch the hole,
than remove the templete and drill using a hole saw bit.
3.
Thread the transfer punch bits into the threaded inserts on the
snorkel.
4.
Slide the snorkel through the hole and press into the body and A
pillar, this will mark where the holes will be drilled.
5.
Remove the inner wheelwell and A piller cover, also remove the
bolts holding the airbag in place. DO NOT REMOVE THE AIR BAG.
6.
Drill the marked holes, on the pillar make sure you drill all of the way
through.
7.
On the inside of the pillar use a uni bit to enlarge the hole to 3/4in
8.
Attach the sleeve to the lter adapter and tighten the clamp.
9.
Attach the threaded stud to the A pillar insert and press the snorkel
into the sleeve and tighten the clamp.
10. Attach the snorkel to the body using the hardware provided.
11. ReInstall the air bag and pillar cover and wheelwell.
MY
MAKE
MODEL
ENG.
07-10
TOYOTA
TUNDRA
5.7L
RECOMMENDED SERVICE PARTS
PART NO.
READ INSTRUCTIONS THOROUGHLY BEFORE DISASSEMBLING.
DO NOT SKIP ANY STEPS. ANY QUESTIONS ON A VOLANT KIT
MAY BE REFERRED TO OUR TECH SUPPORT LINE AT
(909) 481-3888 OR VISIT OUR WEBSITE AT
Volant Performance
Rancho Cucamonga, CA 91730
(909) 481-3888 Tech Support
(909) 476-1491 Fax
WARNING: OVER TIGHTENING HARDWARE MAY ALTAR THE INTEGRITY OF
THE VOLANT AIR INTAKE SYSTEM.
BEFORE ROAD TESTING
1.
Start engine, leaving the transmission in park and securing the parking brake.
2.
Make sure to look and listen for any unusual noises or air leaks. Repair
problems if needed.
3.
Once completed it will be necessary to check periodically for realignment and
tightening of all connections.
4.
Once all tests are completed, enjoy the performance of your new Volant Air
Intake System.
CARE AND CLEANING
Check the cotton reusable lter periodically and remove any excessive dirt build-up
by tapping the lter on the ground and brushing off the loosened dirt. Clean the
lter by using Volant’s Filter Recharger Kit. Volant’s Filter Recharger Kit is designed
to restore original air ow. Re-oil every 10,000 miles without cleaning to improve
ltering in sand and dirt. Clean only when dirt is very excessive or 50,000 miles.
INSTALLATION INSTRUCTIONS PART NO.
Installation Instructions:
RECOMMENDED SERVICE PARTS
APPLICATION GUIDE
INSTALL