Dowco Power Sports Tank Bag Magnet Mount - Manual

Rally Pack™
Value/Deluxe Series Tank Bag System With Map
Pocket Installation Instructions
Congratulations on your purchase of a Rally Pack
Tank Bag System. Assembled to your motorcycle,
the system will provide extra storage for cell phones,
maps, clothes and other items for short or long trips .
Please carefully read the information below before
installation
.
Universal Harness Installation
1. Remove seat
2. Locate front of harness with two large quick-
release buckles.
3. Disengage buckles and position harness loosely
on gas tank between steering head and front of
tank.
4. Thread front strap around steering post and clip to
harness buckles.
5. The rear of the harness contains one web strap
with slide lock and quick release buckle. Slide web
strap under tank mounting or around frame.
6. Weave end of web strap through tri-glide(slide
adjustment). Buckle to harness.
7. Adjust front and rear of harness using the
combination of slider locks and the quick-release
buckles to securely fasten the harness on the gas
tank.
8. Check to make sure harness is centered on tank.
9. Reassemble seat with care. Slide locks should not
interfere with attachment. If you encounter
interference, adjust slider locks.
Magnetic Mount Harness Installation
Place and center magnetic unit directly on METAL
tank. Position to conform to tank profile and not to
interfere with full left or right steering.
NOTE: Do not put anything with credit cards near the
magnets!
For Deluxe Version Only:
1. Unfasten velcro on top portion of harness.
2. Position tank bag in center of harness with zipper
facing to the rear.
3. Insert plastic tab from tank bag into pocket of
harness. Press to secure velcro.
4. Assemble zipper and zip tank bag to harness.
Overloading any tank bag will result in a high center of
gravity, which will cause bike to become top heavy and
susceptible to unexpected tipping, especially on lean-in
while negotiating high speed turns. MAXIMUM ALLOW-
ABLE LOAD LIMIT IS 5 LBS.
Care & Cleaning:
This product is supplied with a gasoline and scratch
resistant neoprene layer. However, care should be
taken to avoid gas spills and a heavy buildup of dust
and/or dirt under the harness. Excessive dust and/or
dirt may become embedded in the neoprene, which
may lead to scratches in the painted finish. Wiping
with a mild bike wash detergent and applying a good
quality wax will reduce the chance of
scratching.Remove the bags before washing the
bike.Use a mild detergent and soft brush to remove
dirt or road grime from the bags. Rinse thoroughly
and allow to air dry before using. Do not put in washer
or dryer. Dry-cleaning is not recommended.
Note:Your bags are manufactured from heavy-weight
water-proof polyester materials. However, in the event
of heavy rain, moisture may enter the bags through
seams or zippers. It is highly recommended that
important papers, valuable items, or clothing be
wrapped in plastic for added protection
DOWCO, Inc.
4230 Clipper Drive
Manitowoc, WI 54220
Fax: 920-682-5891
Phone: 1-800-558-7755
Item # 141464-00
Rev. 1/17/06
Printed in China
The Universal Harness must be installed so as not
to interfere with full left or right steering. Failure to
ensure that adequate steering is available will
result in serious injury.