Gorman-Rupp Pumps 82E-GX270 1501111 and up User Manual
Page 27
OM−06216
80 SERIES
MAINTENANCE & REPAIR
PAGE E − 9
aid this installation. The I.D. of the tube should be
approximately the same size as the I.D. of the seal
spring.
Install the spacer sleeve and seal spring.
Subassemble the outboard stationary seat, pack-
ing ring and stationary washer. Press this unit into
the lubricated seal liner. Install the outboard rotat-
ing element with the chamfered side toward the
impeller.
After the impeller and grease cup have been in-
stalled, lubricate the seal as indicated in LUBRI-
CATION, Section E.
Impeller Installation And Adjustment
(Figure 2)
Inspect the impeller, and replace it if cracked or
badly worn. Install the same thickness of impeller
shims (31) as previously removed, and screw the
impeller onto the shaft until tight.
A clearance of .010 to .020 inch (0,25 to 0,51 mm)
between the impeller and the intermediate is nec-
essary for maximum pump efficiency. Measure this
clearance and add or remove impeller shims until
this clearance is reached.
NOTE
Be sure the intermediate is tight against the pedes-
tal while measuring this clearance.
Install the automatic grease cup and piping (8, 9
and 10) in the seal plate. After the impeller is
installed, lubricate the seal assembly as indicated
in LUBRICATION.
Pump Casing Installation
(Figure 2)
If the wear plate (14) was removed for replace-
ment, secure it to the pump casing using the at-
taching hardware (15, 16, 18 and 19) at this time.
Replace the fiber washer (19) if badly worn or com-
pressed.
Install the same thickness of pump casing gaskets
(5) as previously removed, and secure the pump
casing to the intermediate with the nuts (7). Do not
fully tighten the nuts at this time.
A clearance of .008 to .015 inch (0,20 to 0,38 mm)
between the impeller and the wear plate is also rec-
ommended for maximum pump efficiency. Set this
clearance by adding or removing gaskets in the
pump casing gasket set until the impeller scrapes
against the wear plate when the shaft is turned. Af-
ter the impeller scrapes add .010 inch (0,25 mm) of
gaskets.
After the face clearance has been set, tighten the
nuts securing the pump casing to the intermediate.
See Figure 1, and secure the pump casing to the
base with the previously removed hardware. Be
sure to reinstall any leveling shims used under the
casing mounting feet.
Suction Check Valve Installation
(Figure 2)
Inspect the check valve components and replace
as required. Subassemble the check valve weights
(24 and 28) and check valve (27) using the attach-
ing hardware (25 and 26).
Position the check valve assembly in the suction
port with the large weight (24) toward the inside of
the pump casing. Install the suction flange (22) and
secure with the nuts (21). Check the operation of
the check valve to ensure proper seating and free
movement.
Final Pump Assembly
(Figure 1)
Be sure the pump and engine are securely
mounted to the base.
Install the suction and discharge lines and open all
valves. Make certain that all piping connections are
tight, properly supported and secure.
Be sure the pump and engine have been properly
lubricated, see LUBRICATION.
Fill the pump casing with clean liquid. Reinstall the
fill plug (29, Figure 2) and tighten it.
- 83A1-L100EE-X 1215876 thru 1512372
- 83A1-L100EE-X 1512373 and up
- 82E1-L100EE-X 1215875 thru 1518663
- 82E1-L100EE-X 1518664 and up
- 82D1-EX13-X 1390156 and up
- 82D1-1B20-X 1460627 and up
- UNIT 608-A 1347755 thru 1395613
- UNIT 608-A 1395614 and up
- UNIT 608 1347755 thru 1395613
- UNIT 608 1395614 and up
- PA6C60-4045T-ESP 1303082 thru 1450295
- PA6C60-4045T-ESP 1450296 thru 1479000
- PA6C60-4045T-ESP 1479001 thru 1302081
- PA4A60-4024T-ESP 1446296 and up
- PA12A60-B-6068H-ESP 1501367 and up
- PA10A60-4045H-ESP 1423416 thru 1485219
- PA10A60-4045H-ESP 1485220 and up
- V6A60-D914L6 1454318 and up
- V6A60-4045T 1456487 and up
- V4A60-D914L3 1459605 and up
- V3A60-D914L3 1438800 and up
- V3A60-4024T 1435149 and up
- T8A60S-F6L 1278434 thru 1318430
- T8A60S-F6L 1318431 and up
- T8A60S-4045H 1514489 and up
- T6A65S-F4L 1408479 and up
- T6A60S-F4L 1263998 thru 1313298
- T6A60S-F4L 1313299 and up
- T6A60S-4045T 1443416 and up
- T4A60S-F3L 1264856 thru 1314224
- T4A60S-F3L 1314225 and up
- T4A60S-4024T 1320259 and up
- T10A65S-6068T 1413937 and up
- T10A60S-6068T 1268074 and up
- VS6A60-B 1321070 thru 1352520
- VS6A60-B 1352521 and up
- VS4A60-B 1333878 thru 1400844
- VS4A60-B 1400845 and up
- VS3B60-B 1359952 and up
- VS3A60-B 1321968 thru 1368379
- VS3A60-B 1368380 and up
- V6A60-B 1321070 and up
- V4A60-B 1333878 and up
- V3B60-B 1368385 and up
- V3A60-B 1321968 and up
- 08C1-GA 1026171 and up
- 06D3-GHH 1071445 and up
- 06D17-GAR 708768 thru 1000782
- 06D17-GAR 1009424 and up
- 06D1-GAR 1005542 thru 577661
- 06C1-GAR 1289163 and up
- 06C1-GA 1005575 and up
- 04E1-GHH 1076270 and up
- 04E1-GA 1171927 and up
- 03H3-GR 285579 and up
- 03H3-GL 320347 and up
- 03H1-GR 287634 and up
- 03H1-GL 282480 and up
- 02F1-GR 642659 and up
- 02F1-GL 654607 and up
- 88B2-F5L 1323330 and up
- 88A2-F6L 1306307 thru 1341411
- 88A2-F6L 1341412 and up
- 86A2-F4L 1242877 thru 1322537
- 86A2-F4L 1322538 and up
- 86A2-F3L 1022351 and up
- 86A2-F3L 1257390 thru 1330588
- 86A2-F3L 1330589 and up
- 86A2-4024H 1535998 and up
- 84A2-F3L 1348524 and up
- 84A2-4024H 1488564 and up
- 83B52-GX390 1324570 and up
- 83A2-GX270 1423221 and up
- 82E2-GX270 1451696 and up
- 82D2-GX160 987917 and up
- 82D1-GX160 1257391 and up
- 810A2-F6L All serial numbers
- 810A2-F5L 1299234 thru 1322932
- 810A2-F5L 1322933 and up
- 810A2-4045T 1529947 and up
- RS5A32-BAR All serial numbers
- U6B65S-B /F 1289655 and up
- U6B60S-B /FM 1289612 and up
- U6A60S-B /F 1289665 and up
- U4B65S-B /F 1298951 and up
- U4B60S-B /FM 1289525 and up
- U4A60S-B /F 1289519 and up
- U3B65S-B /F 1292028 and up
- U3B60S-B /FM 1289509 and up
- U3A60S-B /F 1289513 and up
- T6A3-B /F,/FM
- T4A3-B /F,/FM
- T3A3-B /F,/FM
- T2A71-B /F,/FM
- T2A65-B /F,/FM
- T2A61-B /F,/FM
- T2A60-B /F,/FM
- T2A3-B /F,/FM,/WW
- 13E2-12LD477 S/G 1345995 and up
- 13D1-L70EE S/G 1264232 and up
- 13D1-L70EE 1258889 and up
- 13D1-GX270 1421809 and up
- 14D1-GX390 All serial numbers
- 13D-GX270 1421807 and up
- 13A52-GX390 1371656 and up
- 12D1-1B20 1463862 and up
- 12D-1B20 1483730 and up
- 112D60-B-TCD914L6 1520501 and up
- 16D60-F3L 1270259 thru 1318306
- 16D60-F3L 1318307 and up
- 16D60-4024T 1318311 and up
- 16C20-F5L 1338868 and up
- 16C20-F4L 1317844 and up
- 16C2-F5L 1338631 and up
- 16C2-F4L 913960 thru 1013565
- 16C2-F4L 1237525 thru 1319250
- 16C2-F4L 1319251 and up
- 16C2-4045T 1514991 and up
- 16A2-F3L 1317807 and up
- 16A2-4045T 1514795 and up
- 14D52-12LD477 S/G 1344732 and up
- 14D2-12LD477 S/G 1348079 and up
- 14D1-GX390 1142746 thru 1325667
- 14D1-GX390 1325668 and up
- 14C20-F3L 1319349 and up
- 14C20-4024T 1303140 and up
- 14C2-F3L 1319322 and up
- 14C2-4024T 1317426 and up
- 13E52-GX390 1368838 and up
- 13C20-B 710764 and up
- 13C2-B 715157 and up
- 13A2-B 710664 and up
- 13A20-B 712987 and up
- 13A22-B 1063371 and up
- 13A65-B 776101 and up
- 13A9-B 733170 and up
- 12C20-B 1341727 and up
- 12C2-B 722995 and up
- 12B9-B 723228 and up
- 112E60-B 1408480 and up
- 112G60-B 1214462 and up
- 12B2-B 723756 and up
- 12B20-B 1340494 and up
- 12B22-B 1059806 thru 1343819
- 12B22-B 1343820 and up
- 12B65-B 776101 and up
- 11 1/2A65-B 776101 and up
- 11 1/2A9-B 376069 and up
- 112A20-B 814882 and up
- 112B60-B 758209 and up
- 112C60-B 782312 and up
- 112D60-B 1288322 and up
- 11 1/2A3-E2 3P 1045642 and up
- 11 1/2A3-KW1.5 3P 1214536 and up
- 11 1/2A52-B 348418 thru 1241126
- 11 1/2A52-B 1241127 and up
- 11 1/2A52-E2 1P 1235018 and up
- 11 1/2A20-B 519865 and up
- 11 1/2A22-B 1060190 and up
- 11 1/2A3-B 348418 and up
- 11 1/2A2-E2 3P 1046838 and up
- 11 1/2A2-B 347543 and up
- 14C20-B 740693 and up
- 14C2-B 740693 and up
- 14A22-B 1064248 and up
- 14A65-B 776101 and up
- 14A2-B 740693 and up
- 14A20-B 740693 and up
- 16A22-B 1068713 and up
- 16A20-B 818301 and up
- 81 1/2P47A-E2 1P 801799 and up
- 81 1/2P47A-E2 3P 801781 and up
- 81 1/4A3-B 859498 and up
- 81 1/4A3-E.33 3P 794462 and up
- 81 1/4A3-X.50 1P 794462 and up
- 81 1/4A3-X.50 3P 794462 and up
- 81 1/2P47A-B 801848 and up
- 81 1/2E9-B 334698 and up
- 81 1/2E52-B 1271304 and up
- 81 1/2E3-X1.5 3P 387385 and up
- 81 1/2E3-X1.5 1P 387385 and up
- 81 1/2E3-E1 3P 318671 and up
- 81 1/2E3-E1 1P 318671 and up
- 81 1/2E3-B 341115 and up
- 81 1/2D52-B 1286723 and up
- 81 1/2D3-X1 3P 326949 and up
- 81 1/2D3-X1 1P 326949 and up
- 81 1/2D3-X.75 3P 246091 and up
- 81 1/2D3-X.75 1P 246091 and up
- 81 1/2D3-E.75 3P 252952 and up
- 81 1/2D3-E.75 1P 252952 and up
- 81 1/2D3-E.50 3P 262113 and up
- 81 1/2D3-E.50 1P 262113 and up
- 81 1/2D3-B 359802 and up
- 81 1/2B52-B 1240557 and up
- 81 1/2B3-B 263741 and up
- 81 1/2B2-B 259506 and up
- 81 1/2A52-B 1233759 and up
- 81 1/2A3-B 275382 and up
- 81 1/2A2-B 253703 and up
- 86B3-B 819132 and up
- 86B52-B 1336823 and up
- 88A2-B 818301 and up
- 88A20-B 818301 and up
- 88A3-B 818301 and up
- 88A52-B 1363098 and up
- 88B2-B 818301 and up
- 88B3-B 818301 and up
- 86B2-B 819132 and up
- 84A3-B 818301 and up
- 84A52-B 1325165 and up
- 84B2-B 667409 and up
- 84B3-B 664926 and up
- 84B31-B 1364371 and up
- 84B52-B 1324770 and up
- 86A2-B 819132 and up
- 86A3-B 819132 and up
- 86A52-B 1329204 and up
- 83B52-B 1329030 and up
- 83C2-B 814600 and up
- 83C20-B 814600 and up
- 83C3-B 814600 and up
- 83C52-B 1337266 and up
- 83D20-B 733876 and up
- 84A2-B 818301 and up
- 82H65-B 1015831 and up
- 83A2-B 732174 and up
- 83A3-B 734045 and up
- 83A52-B 1332148 and up
- 83B2-B 1063841 and up
- 83B3-B 1059514 and up
- 83B31-B 1364724 and up
- 82E52-B 684918 thru 1327231
- 82E52-B 1327232 and up
- 82H2-B 716064 and up
- 82H20-B 737048 and up
- 82H3-B 716123 and up
- 82H52-B 252751 thru 1325647
- 82H52-B 1325648 and up
- 82D52-B 1244432 and up
- 82E2-B 717191 and up
- 82E20-B 717487 and up
- 82E3-B 717465 and up
- 82D3-B 274955 and up
- 82D2-B 344003 and up
- 810A2-B 819132 and up
- 81 1/4B3-E.33 1P 24971 and up
- 81 1/4A52-B 1287356 and up
- 02K3-X2 1P 312560 and up
- 02K3-X2 3P 312560 and up
- 02K31-B 597564 and up
- 02K31-X2 1P 605416 and up
- 02K31-X2 3P 597658 and up
- 02K52-B 1255789 and up
- 03A20-B 751140 and up
- 02E3-B 284632 and up
- 02K11-B 740364 and up
- 02K11-X2 1P 384050 and up
- 02K11-X2 3P 684441 and up
- 02K3-B 283128 and up
- 02K3-E2 1P 280663 and up
- 02K3-E2 3P 281903 and up
- 02D3-E1 1P 247741 and up
- 02D3-E1 3P 251494 and up
- 02D3-X1.5 1P 338134 and up
- 02D3-X1.5 3P 254341 and up
- 02D3-X2 1P 357921 and up
- 02D3-X2 3P 357921 and up
- 02C3-X1.5 3P 254340 and up
- 02C3-X2 1P 643647 and up
- 02C3-X2 3P 390873 and up
- 02D3-B 260276 and up
- 02C3-X1.5 1P 262109 and up
- 02C3-X.75 3P 237887 and up
- 02C3-X.75 1P 263824 and up
- 02C3-E.75 3P 241492 and up
- 02C3-E.75 1P 244229 and up
- 02C3-B 259749 and up
- 04B52-B 1346496 and up
- 04C3-B 407671 and up
- 04C52-B 1399307 and up
- 06B20-B 806819 and up
- 06B3-B 806819 and up
- 06B52-B 1332442 and up
- 03J1-B 713013 and up
- 04A20-B 818101 and up
- 04A3-B 818101 and up
- 04A52-B 1326393 and up
- 04B3-B 806819 and up
- 04B3-F4L 1242057 thru 1316965
- 04B3-F4L 1316966 and up
- 03E1-B 450930 and up
- 03F3-B 463273 and up
- 03F52-B 1329227 and up
- 03H1-B 710816 and up
- 03H1-GX390 1178614 and up
- 03C51-B 1341129 and up
- 03C31-B 594106 and up
- 03C11-B 741793 and up
- 03B51-B 1371962 and up
- 03B31-B 594101 and up
- 03A52-B 1327255 and up
- 03A3-B 751140 and up
- T3A71S-B /F,/FM
- T4A3S-B /F,/FM,/WW,/WWS
- T10A3S-B /FM,/WW
- T10A60S-B /FM,/WW
- T10A61S-B /FM
- T10A65S-B /FM
- T10A71S-B /FM
- T3A3S-B /F,/FM,/WW,/WWS
- T3A60S-B /F,/FM,/WW
- T3A61S-B /F,/FM
- T3A65S-B /F,/FM
- T4A60S-B /F,/FM,/WW
- T4A61S-B /F,/FM
- T4A65S-B /F,/FM
- T4A71S-B /F,/FM
- T4B3S-B /F,/FM,/WW,/WWS
- T4B60S-B /F,/FM
- T4B61S-B /F,/FM
- T4B65S-B /F,/FM
- T6A3S-B /F,/FM,/WW,/WWS
- T6A60S-4045T-ESP 1473164 and up
- T6A60S-5.7 NG-ESP All serial numbers
- T6A61S-B /F,/FM
- T6A65S-B /F,/FM
- T6A71S-B /F,/FM
- T6B3S-B /F,/FM,/WW,/WWS
- T6B60S-B /F,/FM
- T6B61S-B /F,/FM
- T8A3S-B /F,/FM,/WW,/WWS
- T8A60S-B /F,/FM
- T8A61S-B /F,/FM
- T8A65S-B /F,/FM
- T8A71S-B /F,/FM
- 62 1/2D1-CH23 S/G 1211015 and up
- 62 1/2A1-L100 S/G S2 93740 CA and up
- 62 1/2A1-GX390 S/2 93740 CA and up
- 54J20-B 1410811 and up
- 54J2-B 1424552 and up
- VGH4D31-B All serial numbers
- VGH4D31-B 1379872 thru 1211396
- VGH5B31-B 1379872 thru 1211802
- VGH5C31-B 1379872 thru 1211804
- VGH6D31-B 1379872 thru 1208732
- VGH6E31-B 1379872 thru 1208734
- VGH8D31-B 1379872 thru 1208738
- VGH3B31-B 1379872 thru 1208727
- VGH3C31-B 1379872 thru 1208728
- VGH3E31-B 1379872 thru 1208731
- VGH4C31-B 1379872 thru 1210169
- VGH2D31-B 1379872 thru 1211808
- VGH2C31-B 1379872 thru 1208722
- VGH2 1/2D31-B 1379872 thru 1208720
- VGH2 1/2C31-B 1369872 thru 1208718
- VGH2 1/2B31-B 1379872 thru 1210171
- VGH1 1/4D31-B 1364934 thru 1211819
- VGH1 1/4C31-B 1379872 thru 1210741
- VGH1 1/4B31-B 1379872 thru 1210317
- VGH1 1/2D31-B 1379872 thru 1211821
- VGH1 1/2C31-B 1379872 thru 1208714
- VG5C3-B 1188885 and up
- VG6D3-B 1188889 and up
- VG6E3-B 1238969 and up
- VG8D3-B 1221466 and up
- VG2D3-B 1191621 and up
- VG3C3-B 1191580 and up
- VG1 1/4B3-B 1260463 and up
- VG1 1/2C3-B 1316095 and up
- 64K31-B All serial numbers
- 66B2-B 370671 and up
- 66B3-B 407277 and up
- 68A2-B 818301 and up
- 612M60-B 1453214 and up
- 612L20B-B 806819 and up
- 612L20-B 814882 and up
- 610M20B-B 699260 and up
- 610M20-B 688324 and up
- 4D-B 461594 and up
- 3D-X1.5 3P 883504 and up
- 3D-B 883512 and up
- 2D-X.75 3P 652300 thru 1462003
- 2D-X.75 3P 1462004 and up
- 2D-X.75 1P 652300 thru 1462000
- 2D-X.75 1P 1462001 and up
- 2D-E.50 3P 661275 thru 1467824
- 2D-E.50 3P 1467825 and up
- 2D-E.50 1P 649393 thru 1485340
- 2D-E.50 1P 1485341 and up
- PAH8A60C-B 1537579 and up
- PAH8A60-6090H 1487549 and up
- PAH6B60-6068H IT4 1529202 and up
- PAH6B60-6068H 1507875 and up
- PAH6A60C-B 1514055 and up
- PAH6A60-6090H 1487547 and up
- PAH4D60-QSB4.5P 1514254 and up
- PAH4C60C-B 1503565 and up
- PAH4C60-6068H 1532412 and up
- PAH4B60-QSB4.5P 1526774 and up
- PAH4B60-4045H 1484421 and up
- PAH4A60C-B 1512735 and up
- PAH4A60-6068H 1511893 and up
- PAH3B60-4045H 1493144 and up
- PAH3A60C-B 1524589 and up
- PAH3A60-6068H 1522805 and up
- PA6F60-4045T 1521221 and up
- PAV3A60C-B 1511107 and up
- PAV3B60C-3TNV70 1433753 and up
- PAV3C60C-B-E10 460/3 All serial numbers
- PA6C60-C4.4T 1404116 and up
- PA6C60-QSB4.5P 1537244 and up
- PA6C60C-F4L 1318119 thru 1504810
- PA6C60C-F4L 1504811 and up
- PA6C60C-F5L All serial numbers
- PA6C60C-F6L 1423057 thru 1477477
- PA6C60C-F6L 1477478 and up
- PA6B60-6068H 1421583 and up
- PA6C60-4045H 1416490 thru 1485125
- PA6C60-4045H 1485126 and up
- PA6C60-4045T 1416818 thru 1481444
- PA6C60-4045T 1481445 thru 1254713
- PA6C60C-B-E50 460/3 1528569 and up
- PA4A60C-C2.2T 1394774 and up
- PA4A60C-F3L 1303165 and up
- PA4B60-4045H 1417817 thru 1497875
- PA4B60-4045H 1497876 and up
- PA4E71C-3TNV88-SE 1416614 and up
- PA4A60-4024T 1476457 and up
- PA4A60-4045T 1501804 and up
- PA4A60C-B-E30 460/3 1482736 and up
- PA12A60-B-6068H 1435345 and up
- PA10A60-4045H 1452219 thru 1484415
- PA10A60-4045H 1484416 and up
- HSV3A1-HYD All serial numbers
- SE1 1/2A3 115V 1P 1483930 and up
- SE1 1/2A3A 115V 1P 1483930 and up
- SE1 1/2B3-E.33 12V 1483930 and up
- SE2C3 115V 1P 1483930 and up
- SE2C3A 115V 1P 1483930 and up
- SE2D3 115V 1P 1483930 and up
- SE2D3A 115V 1P 1483930 and up
- S2F1-E1 460/3 997771 thru 1225728
- S4B1-E50 460/3 All serial numbers
- S3C18 460V 3P 861279 thru 1217140
- S2A1 115V 1P All serial numbers Control Box
- S3B65-E6 460/3 1217131 thru 861278
- S4A1-E25 460/3 1396155 and up
- S4B1-E50 460/3 1396095 and up
- S6A1-E60 460/3 1401314 and up
- S6B1-E95 460/3 1429736 and up
- S6C1-E35 460/3 1401671 and up
- S8A1-E95 460/3 1429751 and up
- S8B1-E100 460/3 1432260 and up
- SFV4B-X 1531245 and up
- SFV4C 1474143 and up
- SFV4D 1468407 and up
- SFV4E 1491311 and up
- SFV3A 1473393 and up
- SFV3B 1473390 and up
- SFV4A 1476537 and up
- SFV4B 1468408 and up
- SFDV4A 1476538 and up
- SFDV4B 1520149 and up
- SFDV3B 1520902 and up
- SFDV3A 1482269 and up
- SF6C All serial numbers
- SF6B All serial numbers
- SF4C 1528832 and up
- SF4B 1504502 and up
- SF4A-X 1531245 and up
- SF4A 1488019 and up
- SM3B1-X6 460/3 All serial numbers Control Box
- SM4D65-X10 460/3 915775 and up
- 4D-X3 1P