Installation / owners manual, Goose box – Reese 94621 GOOSE BOX User Manual
Page 6
2009 Cequent Performance Products, Inc
Sheet 6 of 7
94621IN
3/6/2012
Rev. C
Form: F205 Rev A 5-6-05
BEFORE EACH TRIP:
1. CHECK YOUR EQUIPMENT: Check that condition of all of your towing equipment and keep it in top condition.
2. Check to see that all bolts are properly tightened.
3. Check that the airbag pressure is set for your coach. (The label in rear should be in the green zone.)
ADJUSTING THE AIR SPRING
1.
Perform the hitching procedure before adjusting suspension air pressure.
2.
With trailer hitched to truck and landing gear / jacks retracted, Add air to the air spring at the valve shown in figures 12A, B, & C.
3.
Continue adding air until the label on the rear driver’s side is in the green. (Figure 12C)
Note: Do NOT exceed 50 psi. Starting Operating Pressure Should Be Around 35-40 psi.
4. It may be helpful to put tow vehicle in drive, move a few inches, and then apply brake.
This will jounce the unit and let it find it’s natural position.
5. Recheck Air
The label is a good reference for setting air pressure in the spring, if more performance is desired the air bag
pressure can be adjusted to suite your preference. A good starting point for pressure setting is 35-40 psi.
(Do Not Exceed 50 psi). If the ride is too soft, add more pressure. If the ride is harsh, remove pressure.
Figure 12 A
Installation / Owners Manual
Goose Box
MAINTENANCE:
1.
Grease coupler shaft from fitting in back of coupler before each use and grease goose ball before each use..
2.
Keep Goose Box painted to prevent rust and maintain a good appearance. (Do Not Paint Over Labels)
3.
No special instructions for storage, perform normal maintenance when taking out of storage and using again.
Figure 12 B
Figure 12 C
Air Bag Fill
Fill Label Showing
To High On Pressure
Past Yellow Area
Fill Label Not Showing
To Low On Pressure
In Lower Yellow Area
Fill Label Showing
In Green Area
Pressure Is OK
Note:
The Goose Box is equipped with an
automatic air relief valve. If you try to
over inflate the bag the relief valve will
pop, releasing excess air. The system can
help you adjust the air bag. Fill to green
area, and then add a few more pounds of
air pressure. Drive your unit and step on
the brake a few times. Excess air will vent
off. You should be left with the unit near
or in the green area. This should be your
most optimum air pressure.
Air Bag Fill
Air Bag Fill