Dee Zee DZ371953 - Manual

3" SIDEBAR
2006-2011 HONDA RIDGELINE
Page 1 of 3 11/8/2011 Rev2 (DP)
PARTS LIST:
1 Driver/Left Sidebar 1 Driver/Left Rear Mounting Bracket
1 Passenger/Right Sidebar 1 Passenger/Right Rear Mounting Bracket
1 Driver/Left Front Mounting Bracket 12 8-1.25mm x 30mm Hex Bolts
1 Passenger/Right Front Mounting Bracket 12 8-1.25mm x 25mm Hex Bolts
1 Driver/Left Center Mounting Bracket 24 8mm Lock Washers
1 Passenger/Right Center Mounting Bracket 24 8mm x 24mm x 2mm Flat Washers
PROCEDURE:
1. REMOVE CONTENTS FROM BOX. VERIFY ALL PARTS ARE PRESENT. READ INSTRUCTIONS
CAREFULLY BEFORE STARTING INSTALLATION.
2. Starting on the driver side front of the vehicle, locate the (2) factory threaded holes in the bottom of
the outer frame channel, (Figure 1). NOTE: The threaded holes may be filled with plastic plugs or
covered in insulation. Remove plugs or insulation before proceeding. Repeat this step to locate the
center and rear, (Figure 2), mounting locations. NOTE: There may be (4) sets of threaded holes
along the floor panel. This installation will use the first, third and fourth sets of holes only.
3. Position the driver side Front Mounting Brackets up to vehicle. Hang the Bracket from the two
threaded holes using the provided (2) 8mm x 30mm Hex Bolts, (2) 8mm Flat Washers and (2) 8mm
Lock Washers, (Figure 3). Snug but do not tighten hardware at this time.
4. Repeat Steps 2 - 3 to install the Center and Rear Mounting Brackets, (Figures 4 & 5).
5. Carefully position the driver Sidebar onto the Mounting Brackets and attach it using the included (6)
8mm x 25mm Hex Bolts, (6) 8mm Flat Washers and (6) 8mm Flat Washers, (Figures 3 - 5). Snug
but do not tighten hardware at this time.
6. Align Sidebar properly and tighten all hardware.
7. Repeat Steps 2 - 6 for the passenger Sidebar installation.
8. Do periodic inspections to the installation to make sure that all hardware is secure and tight.
Passenger/Right
Side Rear Mounting
Bracket Driver/Left Side Rear
Mounting Bracket
Driver/Left Side Front
Mounting Bracket
Passenger/Right Side
Front Mounting Bracket
Passenger/Right
Side Center
Mounting Bracket Driver/Left Side
Center Mounting
Bracket
Driver/Left Side Sidebar
Passenger/Right Sidebar
Front Rear