Bryant 364AAN - Manual

A U G / 2 6 / 2 0 0 8 / T U E 1 0 : 0 1 UTC TECH PUB F A X N o , 3 1 7 2 4 0 5 6 6 2
and operating
DGWNFLQW/HGRIZONTAL;
G1ÜFIBED FURNACE. : ■
364AAN
Cancels: 'New II â64A-7d7Î
U
Index - ,
SAFETY CO^rsiDERATIONS......................... ,................
Minimum Clearanct t,p Combustibles................ .
INTRQDXJipXiOii ............................................ ..............
LocAjio>f.x;„:„„;;.:..2.„„
..................
Air for Combustion anji Vcntilatioi^,......--- -............
Ductwork Recomniendatipns ................ ......li-.i..--,..,..
ve ^ in , c 2 instruc . tiqn &‘,.„,1.......................... ............... .
Pre“InstaJl8ition;VentOSystem Inspection............... ....
Masonry Chimney................................................ .i-;..
Factpiy.-PuiJt Chimnpys..,:......................................
Horizontal :Venting,„........................................... .......
OIL BURKERi...... ...................................... ......................
OIL CONNECTIONS............ J........................... .............
BAROMETRIC DRAFT CONTROL;;..-,...
ELECTRICAL',........
FILTERS
Page
.... 1^2
....... 2
..........2
-A-X2^
.....2-3
......3-4
....... .4
-4
:......4
SAFETY considerations
....... 4
.........4
........ 4
.......4
........ 4
........5
.......;5
......,...,5 Keeping Filters Clean.
REVERS.lNQ-INSTitUGTIONS FOR REAR FLUE,
OPTrQfe,:i-.„;:/;v..i...v..;;.;it..;......................................... :5-6
ASSEMBLYTNSMCTIONS......................... ......... ........ „. 7.78
OPERATIONAL CHECKOUT......................................
St^-Up ..........................................:............
Recommended Installation Practipcs and
. Combustion Check,.,.,,.......................................................S-9
Fan;Adju5ihne)^^ ..................................................... .........,..9,,
Limit^CqntTol Check...,,.......,,,........ .......... ............... ........... „,,9
For Year Rouiid ,^r Conditioning,.,,:,,.,.....,......... ,,...,,..,....,1,9
Heating..........,.^
Cooling
....... ............................. ,-.'-;9
'Gpnstant^jBjoiwer Switch.
MAINTENANCE
Oil Burner.-.,,ft
Heat Exchanger and, Flue Pipe..,.
Blower Removal
Airflow
Dimensional Drawing-.............. .-
E arometne. Damper'Locati ons..... ..
Wiring Diagram...............................
USER^sllNFORMATION........ ....... ;
Here's Hbw Your Heating System Works........................ d5
Preparing Your Furnace For Operation
,',,■.-15
Lighting Your Furnace........................................... ....
Turning Off Your Furnace........ ..................... „■.fj.'l:.......15
'i' 'V '>■ ■
FOR YOUR SAFETY
DO NOT STORE .OR. USE GASOLINE OR
OTHER fLAMîVïABÜE YARORS A^ LIQ­
UIDS IN XHE-YlCtNITYLOFATHIS OR.ANY
OTHER APPLIANCE, _ .....- ,, ■AAil.
DO NOT ATTEMPT TO START THE BURNER
WHEN EXCESS OIL HAS ACGUMtlLATED,
WHEN THE FURNACE IS FULL GF_ VAPOR, -
OR WHEN THE COMBUSTION CHAMBER IS^
VERY HOT.
.." 1 Ч;
■ ■ .. .... ..... ....... ...
ж
WARNING: For use with grade-2 Fuel Oil liiaximum.
Do not use Gasoline, Crankcase Oil, or any Oil contain-^
ing Gasoline! .... ..... - - -
. ,S:I .
A
CÀüf IpW:' burn/garbi^e^ or 'papér in 'the hc^tihg"
system and never leave rags or paper around .fhennit;.
A
CAUTION,' These .^instfuctio'ns'hre,intended to be',^used
by qualified personnel who have been trained in installing
this type of furnace. Installation of this furnace by an
unqualified person
damage an,d/pi:.
a hazardous condition which-'may icad to bodily harm-
AJ] local and national code requirements governing installation of
oil burning equipment^ wiring, and flue ¿onnecdons'^nitist bë
followed. Some of thé codes (issued by thé Canadian Standards
Association) the Niiiqnhl ‘Fire Protection Agencÿ; ahd/oPthc
American National StandardsThstitute) th'atiihaÿ bë’ appiioiijie 'aje",
CSAB1^9 ' ‘mSTALLA^ON CODEfbR'''
,oiL,Büiüjiï^ckû0ffMEi^
‘^ ANSiONFPA 31 ‘ INSTALLATION OF OIL BURNIN<5
-EQUIPMENT ' '
‘ ANSÏ/NFPA90B WARM AiR HEATING AND
conditioning ’SYSTEMS
^ AN5I/NFFA211
.,ANSI/NFPA 70
eSA C22.1
CHIMNEYS, FIREPLACES, VENTS,
AND 'SOLID FUEL BURNING
APPLIANCES ' '
NATIONAL ELECTRICAL CODE
CANADIAN ELECTRIOAL CODE ’
- 1 -