EarthQuake W2700B - Manual (Page 5)

Operator's Manual
27-Ton Log Splitter, W2700
Check for parts online at www.getearthquake.com or call 800-345-6007 M-F 8-5 CST 5
Repair and Maintenance Safety
• Do not operate your log splitter in poor mechanical condition
or when in need of repair.
• Periodically check that all nuts, bolts, and screws are tight-
ened.
• Always perform recommended maintenance procedures
before using your log splitter.
• Do not alter your log splitter in any manner such as attach-
ing a rope or extension to the control lever or adding to the
width or height of the wedge.
• Replace all damaged or worn parts immediately.
• Never tamper with the engine in order to operate at exces-
sive speeds. The maximum engine speed is preset by the
manufacturer.
• Do not service or repair your log splitter without removing
the spark plug wire.
• All replacement parts must meet manufacturer’s specifica-
tions.
Towing Safety:
• Obey all federal, state and local regulations when towing on
public roads and highways.
• Before towing, be certain that your log splitter is correctly
and securely attached to the towing vehicle and that a safety
chain is in place.
• Never carry any cargo or wood on your log splitter. Do not
allow anyone to sit or ride on your log splitter.
• Before using your log splitter, disconnect it from the towing
vehicle.
• When turning, parking, crossing an intersection, and driving
in all situations allow for added length of your log splitter.
• Be careful when backing up.
• Adjust towing speed for terrain and conditions.
• Never operate your log splitter under the influence of alco-
hol, drugs or medication. A clear mind is essential for safety.
• Maximum speed of 45 mph is recommended when towing
log splitter.
Fire Prevention:
• Never operate your log splitter near a flame or spark. Hydrau-
lic oil and gasoline are flammable and can explode.
• Do not fill the gas tank while the engine is hot or running.
Allow the engine to cool before refueling.
• Never smoke while operating or refueling your log splitter.
Gas fumes can easily explode.
• Only refuel your log splitter outdoors in a clear area. Always
use an approved fuel container. Always replace the gas cap
securely.
• If gas is spilled, move machine away from the area of the spill
and avoid creating any source of ignition until the spilled gas
has evaporated or been cleaned up.
• Keep a Class B fire extinguisher nearby when operating your
log splitter in dry areas as a precautionary measure against
possible flying sparks.
• Completely drain the fuel tank prior to storage. Do not si-
phon by mouth.
• Always store gasoline in an approved, tightly sealed con-
tainer. Store the container in a cool, dry place. Do not store
indoors or near a heating appliance.
• When storing gasoline or equipment with fuel in the tank,
store away from furnaces, stoves, water heaters or other
appliances that have a pilot light or other ignition source
because they can ignite gasoline vapors.
Hydraulic Safety:
• The hydraulic system and mechanical parts of your log split-
ter require careful inspection. Be sure to replace any dam-
aged hydraulic component.
• Fluid escaping from a very small hole can be very difficult
to see. Do not check for leaks with your hand. Escaping fluid
under pressure can have sufficient force to penetrate skin,
causing serious personal injury or even death. Leaks can be
located by passing a piece of cardboard or wood over the
suspected leak. Look for discoloration.
• If injured by escaping fluid, see a doctor at once. Serious in-
fection or reaction can develop if proper medical treatment is
not administered immediately.
• Should it become necessary to loosen or remove any hydrau-
lic fitting or line, be sure to relieve all pressure by shutting
off the engine and moving the control handle back and forth
several times.
• The pressure relief valve on your log splitter is preset at the
factory. Do not adjust the valve. Only a qualified service tech-
nician should perform this adjustment.